Product ID:463-287, SILVERSTONE FINISH
MSDS Date:08/11/1989
FSC:8010
NIIN:00N024260
MSDS Number: BPPTM

DU PONT E I DE NEMOURS & CO INC

1007 MARKET STREET
WILMINGTON, DE 19898
US

Emergency Phone: 800-441-3637/800-424-9300(CHEMTREC)

Info Phone: 800-441-7515/MSDS 302-992-3511

Cage: 18873

E.I. DUPONT DE NEMOURS & CO

WILMINGTON, DE 19898 US

Telephone: 800-441-7515;800-441-9442

Cage: 18873

CONT MAY CAUSE

RTECS: 9999999ZZ

UPPER RESP &/OR LUNG IRRIT W/COUGH, DFCLTY BRTHG,OR

RTECS: 9999999ZZ

MAY CAUSE ALLERGIC SKIN RASH, ITCHING, SWELLING.

RTECS: 9999999ZZ

RPTD/PRLNGD

RTECS: 9999999ZZ

CAUSE EYE IRRIT W/DISCOMFORT, TEARING, OR BLURRED

RTECS: 9999999ZZ

SUCH AS DIZZINESS, HEADACHE, NAUSEA, AND LOSS OF

RTECS: 9999999ZZ

BAKING OVENS MUST BE PROPERLY VENT. AT TEMPS

RTECS: 9999999ZZ

EVOLVED; AMTS INCR AS TEMP INCR.HYDROGEN FLUORIDE IS

RTECS: 9999999ZZ

HIGH CONC CAN CAUSE LUNG DAMAGE, PULM EDEMA/BURNS.

RTECS: 9999999ZZ

HF AND ATTENTION MUST BE GIVEN TO EXHAUST

RTECS: 9999999ZZ

PIGMENT ADDITIVE (NON HAZARDOUS); (NON HAZARDOUS PIGMENT)

GLYCOLS, POLYETHYLENE,MONO ((1,1,3,3-TETRAMETHYL

CAS: 9036-19-5

RTECS: MD0907600

TITANIUM OXIDE; (TITANIUM DIOXIDE) (FLUOROPOLYMER SOLIDS)

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

SILICATE, MICA; (MICA)

CAS: 12001-26-2

RTECS: VV8760000

OSHA PEL 20 MPPCF

ACGIH TLV: 3 MG/M3 RDUST; 9293

OXYGENATED NITROGEN POLYMER

1.

CAS: 100-37-8

RTECS: KK5075000

OSHA PEL 10 PPM, S

ACGIH TLV: 10 PPM, S

52.

CAS: 121-44-8

RTECS: YE0175000

OSHA PEL 25 PPM/15 STEL

ACGIH TLV: 10 PPM/15 STEL; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

1.

CAS: 98-00-0

RTECS: LU9100000

OSHA PEL S, 50 PPM/15 STEL

ACGIH TLV: S,10 PPM/15STEL;9293

2-PYRROLIDINONE, 1-METHYL-; (N-METHYL-2-PYROLIDONE). VP

CAS: 872-50-4

RTECS: UY5790000

SILICA GEL; (AMORPHOUS SILICA)

CAS: 112945-52-5

RTECS: VV7310000

OSHA PEL 6 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL:NORM NOT HAZ. PRODS CONTAIN SML
AMTS OF SOLV AS DESCRIBED BELOW. SKIN/EYE: MAY CAUSE IRRIT/BURNING
OF EYES. RPTD/PRLNGD LIQ CONT MAY CAUSE SKIN IRRIT W/DISCOMFORT &
DERM. INGEST: GI DISTRESS. EX POS TO TEFLON DECOMP PRODS CAN CREATE
INFLUENZA-LIKE SYMP, COMMONLY REFERRED TO AS POLYMER FUME FEVER.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: SYMP DO NOT ORDINARILY OCCUR UNTIL
SEV HRS AFTER EXPOS & PASS W/IN 36-48 HRS. EFTS ARE NOT CUMULATIVE.
EXPOS UAUALLY RSLTS FROM SMOKING TOBACCO/CIGARETTES CONTAM
W/FLUOROCARBON DURING HNDLG/ FROM BRTHG VAPS EMITTED DURING BAKING.
ING 1:CAUSES EYE CORR & PERM INJ.CONT MAY CAUSE SKIN IRRIT
W/DISCOMFORT/ (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION, PREFERABLY MOUTH-TO-MOUTH. IF BRTHG DFCLTY
PERSISTS, OR OCCURS LATER, CONSULT PHYS. EYE: IMMEDIATELY FLUSH
W/PLENTY OF H *2O FOR AT LEAST 15 MINUTES; CALL PHYS.SKIN: WASH
W/SOAP AND WATER. IF IRRITATION OCCURS, CONT PHYSICIAN. INGESTION:
CALL PHYSICIAN IMMEDIATELY AND HAVE NAMES OF INGREDIENTS AVAILABLE.

Flash Point:NONE
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT. H*2O FROM FOG NOZZLES MAY BE USED TO COOL
CLOSED CONTAINERS TO PREVENT PRESSURE BUILDUP.
Unusual Fire/Explosion Hazard:HYDROGEN FLUORIDE IS RELEASED DURING
FIRE.

Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
AVOID SKIN CONTACT AND BREATHING OF VAPOR. CONFINE AND REMOVE WITH
INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:OBSERVE LBL PREC. KEEP AWAY FROM HEAT,
SPARKS AND FLAME. CLOSE CONTAINER AFTER EACH USE. GROUND CONTAINERS
WHEN POURING. DO NOT STORE ABOVE 120F.
Other Precautions:EXPLO RXN MAY OCCUR ABOVE 796F W/FINELY DIVIDED
FLUOROCARBON & METAL POWDER (ALUMINUM/MAGNESIUM). OPER SUCH AS
GRINDING, BUFFING/GRIT BLASTING MAY GENERATE SUCH MIX.KEEP WET. USE
ADEQ VENT TO CNTRL. D O NOT EXCEED RECOM BAKING TEMP. (ING 19)

Respiratory Protection:DO NOT BRTH VAPS/MISTS. WEAR PROPERLY FITTED
VAP/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA (TC-23C) FOR USE
W/PAINTS DURING APPLIC & UNTIL ALL VAPS AND SPRAY MIST ARE
EXHAUSTED. FOLLOW RESPIRATOR MFR'S DIRECTIONS FOR RESPIRATOR USE.
Ventilation:PROVIDE SUFFICIENT VENTILATION N VOLUME AND PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EMERGENCY EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING AND SMOKING.
Supplemental Safety and Health
% VOLAT:47.1-66.6 % BY WT.EFTS OF OVEREXP: RASH.ING 3:RPTD/PRLNGD
OVEREXP MAY LEAD TO CHRONIC LUNG DISEASE.ING 4:RPTD/PRLNGD LIQ CONT
MAY CAUSE SKIN IRRIT W/DISCOMFORT & DERM.MAY CAUSE EYE IRRIT W/DIS
COMFORT, TEARING/BLURRED VISION. MAY CAUSE IRRIT OF MUC MEMB.ING
5:CONT MAY CAUSE SKIN IRRIT W/DISCOMFORT/RASH. (ING 13)

HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Density:HVR/AIR
Spec Gravity:1.18-1.36
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:APPRECIABLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORSEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AT TEMP >750F HF CAN BE EVOLVED.
AMOUNTS INCREASE WITH TEMP. OXIDES OF HEAVY METALS REPORTED IN
INGREDS SEC, IF ANY.

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. SEND TO HAZARDOUS WASTE WATER TREATMENT PLANT OR
INCINERATE ABSORBED MATERIAL IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REQUIREMENTS. DO NO T INCINERATE IN CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.